Energies, Vol. 18, Pages 6631: Assessment of Potential for Green Hydrogen Production in a Power-to-Gas Pilot Plant Under Real Conditions in La Guajira, Colombia

Energies, Vol. 18, Pages 6631: Assessment of Potential for Green Hydrogen Production in a Power-to-Gas Pilot Plant Under Real Conditions in La Guajira, Colombia

Energies doi: 10.3390/en18246631

Authors:
Marlon Cordoba-Ramirez
Marlon Bastidas-Barranco
Dario Serrano-Florez
Leonel Alfredo Noriega De la Cruz
Andres Adolfo Amell Arrieta

This study presents the operational assessment of a pilot-scale power-to-gas (PtG) facility located in La Guajira, Colombia, which integrates a 10 kW photovoltaic array and a 5 kW wind turbine to power a system with two anion exchange membrane (AEM) electrolyzer of 4.8 kW in total for green hydrogen production. Unlike most studies that rely on simulations or short-term evaluations, this study analyzes nine months of real operating data to quantify renewable energy availability, system capacity factors, and effective hydrogen output under tropical conditions. The results show that the hybrid system generated 7111 kWh during the monitoring period. The comparison of theoretical models with real-time energy production shows a low correlation between the data. The MBE ranged from 1253 to 2988 for the solar system, from −814 to 1013 for the wind system, and from 338 to 2714 for the hybrid system. The RMSE values obtained for each evaluated month ranged from 3179 to 3811 for the solar system, from 928 to 1910 for the wind system, and from 2310 to 4327 for the hybrid system, suggesting that the theoretical models tend to overestimate the energy production of the hybrid system in general terms. From the renewable energy produced in real conditions, 92 kg of hydrogen was produced at an average rate of 9 kg/month, considering the availability of wind and solar resources. However, approximately 300 kWh/month of renewable electricity remained unused because the removable generation did not meet the operating conditions of the electrolyzers, highlighting the importance of improved energy management and storage strategies. These findings provide a real scenario of power-to-gas system performance under Caribbean climatic conditions in Colombia, demonstrate the challenges of resource intermittency and system underutilization, and underline the importance of design systems that allow these intermittencies to be managed for the more optimal production of hydrogen from renewable sources. The outcomes contribute to the understanding of small-scale PtG systems in developing regions and support decision making for future scaling and replication of hybrid renewable–hydrogen infrastructures.